how to lubricate rv holding tank valves and cables

Simply install the valve between your RV's sewer pipes and mount the handle on the end of the cable in a convenient, easy-to-access place. If the RV has three holding tanks, you need a Two Valve Kit plus the Single Valve Kit. The RVers are usually referring to the black 3-inch gate valve on their black holding tank.

Status: Offline. Around $150.00. Lubricate the handles and waste tank valve seal if they stick .

Please do your due diligence when deciding which lubricant to use. The package of grease fittings I bought had and assortment of straight, 45*, and 90* fittings and I chose the 90* one based on the valve access for applying the grease. Price: $76.85. 1. Fixing forever the Nasty Sewer Valve Leak. I believe in the spring I'm going to add the valterra dump gate to the outside edge of the dump tube for both the gray tank and the black tank dumps and not use the OEM valves except when it's below freezing (then I'd dump the lower valves that are below . Permalink. I keep the cables lubed the best i can with silicone lube. Step 2 - Insert the New Dump Valve.

Owner's Manuals. Apr 11, 2017. It's called, "You've got no place to go if your holding tank valves won't open.".

Step 2: Install the Flange Seals.

Your Savings: $11.87. The contents inside the valve dry out causing the valve to . In our case, it has been the persistent small leak in the gray tank valve. The best way to fix this for the long haul is to service the valve.

8 Best San Diego RV Parks And Res... Common RV Electrical Problems And How To Fix Them. A little while ago when running some wiring to install a headphone jack in the Cougar I decided to have a peek inside all areas of the underbelly.As I inspected the area where the gray and black tank valves are located I noticed the black tank valve was developing a crack near the end piece housing the pull rod. Pour through toilet into holding the tank and add approximately 1 gallon (3.8 L) of water. The inner wire in the dump valve cable is a very loose fit in the cable sheath (except for the first few inches of solid rod at the handle end. Popular RV Waterfreshner For Online Sales By RV Parts Shop Canada -. They installed a piece of 5/16 all thread on the valve handle drilled a 1/2 hole thru the side of the frame and ran the all thread straight out and put a T handle on it. Page 64 . Very light editing shows you in detail what's involved . Drain the fresh water holding tank: Remove the drain plug or open the tank drain valve. RV Buying Inspection Checklist. A very simple and inexpensive procedure is used that takes about 5 minutes to perform. A 7/64ths inch drill bit and a #8x1/2 inch stainless steel screw works best to plug the hole.You don't have to use lithium grease, you can use any lubricant that you think is appropriate and one that will not damage the valves in your particular system, which may be different than mine. I doubt you will need to replace or even clean the cables.

Would anyone consider an electric valve??

I have remotely operated valves(cable), my black dump valve started to get difficult to seat. Dave recommends applying silicon to the shaft, rather than WD-40 . Sometimes it produces a small drip from the cap that covers the outlet to the sewage system. How to Replace Dump Valves on RV Holding Tanks ... Name * Email * Website. # 1. Valterra Cable RV Holding Tank Dump Valve - 3 inch, Valterra TC372. Page 66 . 16 Ounces provide 4 treatments for a 40-gallon tank. Many RV owners understand that their tank valves play a crucial role in solving odor problems, preventing clogs, and ensuring that sensors continue to operate correctly. With the valve closed I drilled a 7/32 hole in the bottom flat part near the three inch hub adapter. Forest River, Inc., Interactive Owner's Manuals. I tried to empty my black water tank and the handle pulled open but the tank didn't drain.

Step 1 - Finding the Tank Position and Identifying the Fittings for Replacement. No diagram needed.

), it may be applied either through the inlet or outlet on the rear of the tank. HONEY WAGON A slang term for the sewage pumping truck. For bulkhead installation, the handle folds flat so you can feed it through a hole in the compartment, and included nuts to keep the handle from flattening during use.
Ask Bob Livingston: Potty Talk - Fantasy RV Tours Customer ...

Hi Will, Is that an electric valve? To properly use a black tank system, you need to use a holding tank chemical. Fixing forever the Nasty Sewer Valve Leak. Fleetwood prides itself on building dependable products that help families reconnect one journey at a time. Once out, I lubricated everything that moved, including the shaft with silicone grease. Also put a little on the shafts. Here's an ounce of prevention in a 24-ounce bottle.

The one on the grey tank valve is smaller and is held in place with a retaining clip that has locking tabs on two corners.

To me it seems that when CR built the trailer they glued the PVC and valves so they are very tight and not much movement. nuGen is formaldehyde-free and works further to lubricate drain valves and floats. After draining, close the valve or re-install the plug. I believe this is what he has: remote controlled. Ideally, the material from your holding tank .

Camco 40246 RV TST Drain Valve Lube with Coco Oil - 16 oz ... You can lubricate your valves over and over again on a regular basis with this method.

0 Comments. View Details .

TST RV Waste Holding Tank Drain Valve Lube - 16 Oz part number CAM40246 can be ordered online at etrailer.com or call 800-298-1624 for . If you decide to use air pressure (55 PSI max. Wash out the tanks using some clean water. Water System Maintenance and Troubleshooting . With a 5 Year Limited Warranty! RV Waste Tank Valve Replacement. Out of Stock. You dont even have to get on your knees to locate it .

Enjoy San Diego!

Paul recommends Aqua-Kem (formaldehyde) or Eco Chem (non-formaldehyde) Thetford holding tank chemicals.

There's a parallel to the old "You don't miss your water until your well runs dry" tune. I have tried to resolve the situation by spraying lube into the cable guide at the operating handle end with almost no change. Check on the holding tank and determine which fittings needs replacing.

Thetford Drain Valve Lubricant solves holding tank problems. Valterra Cable RV Holding Tank Dump Valve - 1-1/2 inch, Valterra TC172. Toilet chemicals should be added after the tank is dumped, "recharging" it for the next use.


I have 4 holding tanks on my RV and one of them has a sticky valve. Sunnygrl44. Purchase our RV Drain Sewer Valves here.

I agree having it on the street side would be less than ideal , but a piece of mind is worth alot.

RV Dealer/Owner; Contact; Flooring Center; Bristol Termination Valves - Aftermarket. I asked that to the service manager at a SOB dealership, and he told me they use Murphy's oil.

RV-Dreams Family Member. I use the Valve Lub available at the RV store. I went to dump my black tank today and pulled he cable but nothing came out.

If it is a manual valve I would appreciate the model/part number Also did you replace the valve right at the black tank or was the EZ valve added further down the line towards the end of the sewer pipe? Based on the design of your RV, find the spot where the holding tank is placed. 1 Single switch, sealed IP66, Carlingtech. The cable is a wire housed within a tightly wound spring. Once the valves bolts are out, gently push the pipe apart to liberate the valve. Remove the screw and slide the bracket . Tech Tips: Avoiding Sticky Valves. Or, you can reach out to product advisor here at the factory who can answer your questions and help find just the right Keystone RV for you and your family.

So easy to use, the Valterra Flexible Cable Valve Kit is perfect for any RV, camper, or trailer owner. Anyone with the slightest mechanical capability and the right tools should be able to quickly change the gate valve on the pipe connected to an RV's waste tank.

It works great! This is an independent, unofficial site. When you dump the tanks you just pull the handles. To get to the shaft you will need to remove four more bolts on each valve…easy. From Fleetwood Class A to Fleetwood Class C, browse our archive of high-end motorhomes. In fact it's easily accomplished by most RV handypersons….if the cable broke while the valve was in the fully opened position, that is! Instructional Video No. Join Date: Jan 2011. 3X:Chemistry nuGen's is an advanced nanotechnology formula that creates a self-cleaning nano-shield on holding tank walls, keeping waste in suspension while eliminating odors on contact.

Honey wagons are used to empty RV holding tanks in places without full hookups and dump . Bristol Termination Valves - Aftermarket . De-Winterizing your Aviator. 1 20 Ft, Interface Cable, IP 66.

Black Tank Flush Inlet.

I have tried to resolve the situation by spraying lube into the cable guide at the operating handle end with almost no change.

Toilet. Cable Actuated Waste Valves. If you can, check where the blade seats into the groove.

Winterizing with RV Approved Antifreeze Only. Try to use glasses and buckets in brushing and washing because your water supply is limited inside your trailers and RV when camping. Then I did the same procedure with the black valve. The first thing you should do is thoroughly clean the flanges of any rust or debris. TST is the first safe waste holding tank freshener combined with the strength of a remarkable concentrated cleaner and lubricant. It has a door where you gain access to the city water inlet, fresh water tank fill, cable hookup, dump handles, and tank flush. Having to drop the cover is a pain but once you do, the cables and valves will be visible and assessable. Broken t-handle for Black Water release.

I did not remove these.

Replacement Waste Valve For RV Black Water System. My best guess is valve issue since all these cables have never operated smoothly. If the holding tank is full, however, it presents a greater challenge.

Many RV owners understand that their tank valves play a crucial role in solving odor problems, preventing clogs, and ensuring that sensors continue to operate correctly. Freshen, clean and lubricate your holding tanks - both grey and black water systems - with the first complete RV waste holding tank freshener, cleaner and lubricant.

This is where the problem is at times, the wire within the housing gets rusty. 3000 Gallon Captor Double Wall Liquid Storage Tank - 1.5 Specific Gravity. Since I'm thinking of replacing the cables wondered if anyone has done this job and how difficult it was. RV Gray Valve Repair — REAL-TIME DIY Holding Tank Valve ...

All you do is push a button and the valve opens for you.

It may eventually degrade the rubber making the valve unusable.

I agree , I thought it would be a last result . It comes out right under the storage compartment door where all of your utilities are. Dislodges and flushes stubborn waste deposits and odor . Where should I cut away the underbelly material so that I can gain access to all .

It holds the cable retaining block in the bracket. On my fifth wheel the actual valves are unacessable with only the levers exposed. If you do not like the cable system on most manual sewer valves, there is a good solution.

With all tanks empty and valves closed, I poured a mixture of about 50% mineral oil and 50% water into the grey tank first, let it sit for 1 hr, then opened the valve and captured the mixture in a pail.

#2 another popular option is to open the toilet valve and pour several pots of boiling water down the toilet and into the tank.A black tank is a holding tank that will usually have a valve where you can open the tank's drain to empty the contents away from your rv. Your email address will not be published. 55 Gallon Portable DEF Tank Dispenser.

How To Unclog A Rv Toilet Holding Tank. This should be easy, considering the flange seals are rubber and free of any bolts. In our case, it has been the persistent small leak in the gray tank valve.

Posts: 8. Sure enough, it was the valves. Safe and effective in all RV and marine black, grey, and recirculating tanks. The flange seals are responsible for holding the valve together. The 3-inch valve fits many standard RV's while the 72-inch cable gives you . Additional ABS sheet stock is available in a 5 1/2″ X 9 1/2″ 2 pack.

Black Water Tank Drain Valve. 2012 Bighorn 3070RL - One gray tank valve is not opening. 8 Reasons To Avoid Storing An RV Outside In The Wi... 3 Campfire Breakfast Ideas You Need To Try.

To Ensure Trouble -free Waste Water Operation. Make certain the dump handles are operating properly.

I'm in a 2018 GD Solitude 375 RES. Assume I must go under trailer and remove a section of the underbelly to gain access to the valve. He had to order kits for them as the valves were attached to the tank.

On mine I wait until empty, then fog up the outlet pipe, while working the valve, with silicon spray. It features an easy grip handle and quarter-turn pressure-sealed valve which allows complete control of water flow. My 5er has an enclosed belly. We among the RV motorhome owners who are frequently hassled by a slow leak in either or both the gray and black water holding tank valves. The construction of a dump valve pull cable is significantly different than a brake apply or throttle cable. Comes in 1-1/2" and 3" sizes. Remove the bolts around it using your wrench, and then take off the seals.

Drain Valve Lubricant (1 Piece) (15843) Anyway one solution that I found was using mineral oil to help loosen some of that buildup. Jun 7, 2012. #7.

Actually on our last 5er, it was the valves, not the cables. Perhaps the tank can be pumped out through the toilet by a local septic company, but this is difficult at best. Provides 115%-120% containment of .

Supplying the RV, Pool & Spa, and Plumbing Industries Since 1981 RV PRODUCTS BUS & MOTORCOACH PRODUCTS INDUSTRIAL PRODUCTS POOL & SPA PRODUCTS PLUMBING WHOLESALE Featured Product The All-In-One AFFORDABLE… I wish there was some way to lube those cables up in there and maybe the gate valve itself. Ensure you have adequate time to test each tank by pulling into a full-hookup RV site where you can comfortably park for at least one day. 10 RV Interior Decorating Tips To Update Your Spac... Lebanon KOA Holiday on Salmon Falls River, 10 Offbeat Winter Destinations For RV Snowbirds. This short video will show you how to easily lubricate your RV dump valves without having to disassemble the plumbing pipes and valves. In some cases the 1.5-inch gray valve gets sticky over time especially if the RVer is not using his RV full time. Here's our fix in REAL-TIME DIY.

Required fields are marked * Comment. Poured it in, along with 2-3 gallons of water, let it sit a couple of hours, worked the valve about a dozen times. Page 66 .

Lowest Prices for the best rv treatments from Camco. Page 63 . They dump it into the tank & it works pretty good. It's suitable for all types of RV's — including new, used, motor homes, travel trailers, fifth wheels, slide-ins, and campers. Hi Howard, It will be interesting to learn if this works over time.

Electric Valves- A Better Solution.

01-03-2011, 09:21 AM. Allow your gray and black tanks to fill with water and check for any leaks outside the RV. 5 Gallon Rv Water Tank. Before you can replace the valve, you must flush the tank. A stuck (or broken) holding tank valve is a really big issue if it . Just wanted to share this tip again in case some have not tried this.

Dump Valve Lube - RV-Dreams Community Forum Controls Odors In Portable Waste Tanks And Stored RV Holding Tanks For Up To Six Months Formaldehyde-Free Deodorant Also Lubricates Seals And Cleans Tank Residue $14.81 - $16.45 Thetford® 24 oz. Hook your sewer hose up to the sewer line on your RV and attach the other end to a septic tank or campsite sewer line. You should then turn off the water to your RV holding tanks, and open up the top.

4. Member. Recreational Vehicle Manuals. Date: 07:05 PM Nov 13, 2011. The RV waste valve is one of the RV's simplest components, as it is made up of a standard sliding valve and knob system, but it is also very easily damaged and stuck. Here is the glitch, stuff is expensive to use. Portable Toilets: Pour 4 oz (118 ml) into waste holding tank through the valve opening and add a small amount of water to cover tank bottom. The gray water tank holds the waste water from the sinks and showers.

The Odorlos V77020 Quick Dissolving Holding Tank Treatment is an industrial strength, environmentally friendly toilet chemical so effective that it only takes 4 ounces to eliminate all holding tank odors, liquefy waste and tissue and lubricate valves.

Not yet camped in Hawaii, 2 Canada Provinces, & 2 Territories, I can't be lost because I don't care where this lovely road is going, http://community.webshots.com/user/CaptSkup?vhost=community.

The side-placed jets clean and rinse the smallest, hard to reach places.

I think the handle broke so it won't open the valve. I put in the recommended amount of this drain valve lubricant before winter, and then let it sit in the holding tank until this summer. I had a can of coconut(for dacaris), I used it next time, worked just as well, only $2.00 a can. Foretravel Motorhome Removing Your Holding Tank Valves for ... 30 Gallon Rv Fresh Water Tank. The Odorlos V77002 Liquid Holding Tank Treatment is an industrial strength, environmentally friendly toilet chemical so effective that it only takes 4 ounces to eliminate all holding tank odors, liquefy waste and tissue and lubricate valves. The Best Homemade RV Holding Tank Treatment Revealed

This liquid treatment lubricates your RV's plumbing lines while you drive and prevents sticking valves. Sometimes it produces a small drip from the cap that covers the outlet to the sewage system. Capacities for black water tanks range in 5 gallon to 202 gallons, with tank thickness ranges Maintenance costs depend on the wear and tear of your RV.Easily repair your RV holding tank with Easy ABS Plastic Repair Kit. Ranging from "How-To" videos, pictures and illustrations of various components, systems and features to fully searchable content and downloadable PDFs for individual component owner's manuals, answers are always just a click away. Lubricates holding tank systems and drain valves from the inside; Restores easy valve operation; Coats plumbing lines for smooth tank evacuation

The fresh water tank holds fresh water that can be stored for later use. Description. Our special formula prevents seal wear, sticky drain valves and keeps all the plumbing lines operating smoothly. There was plenty of slack cable to pull the valve out to the storage area. Your Price: $24.12. Step 1: Drain the entire system. Took down the bulkhead in the storage bay and cannot reach the valves of any tank.

You can refer to the design plan of the RV for this. Holding Tanks. Part 1: Find the Leaky RV Waste Tank Valve. On some RV's the handle you see is connected to a cable which is connected to the actual valve located up under the under belly stuff. We've put together a downloadable, PDF version of this RV Buying Checklis t that you can take along for your convenience. RV holding tank heater pads and other UltraHeat products will help protect your water system from the weather, so that you don't have to deal with frozen or ruptured pipes.

When I needed to replace my valves on my 05 PP it was a real pain. To Empty the Holding Tanks. Pour 1/4 bottle in each drain. I can't even close the black water valve now. This short video will show you how to easily lubricate your RV dump valves without having to disassemble the plumbing pipes and valves. After dumping the system I opened the valves and put some wheel bearing grease on a stick and spread it all around the grooves where the blade seats ,then I also put a small amount on the shafts,it made everything work like new,and the grease even helped the valve seals by lubricating them,,,JMHO, Tom. I have had the same problem.

Now I dont have a binding cable and it opens and closes very easy. With this switch, you do not have to worry about the cable breaking when you pull on it.

The reason I asked is that I'm having problems with my black tank valve.

There is a screw on the brackets where the cables meet the valves.

Misawa, Japan Weather Year Round, Warren County Public Schools Calendar 2021-22, Thunder Ridge High School Idaho Falls Boundaries, Chemical Engineering Jobs Abroad, Praying Behind Deobandi, Pcaob Service Organization, University Of Alabama Accounting Faculty, Garage Storage Ceiling Hoist, Mini Golf Stars 2 Unblocked, Be Careful What Is Done In The Dark,